Change Car Particulate Filter (DPF) Ford F-150

Change Car Particulate Filter (DPF)

Easy 0h45 ~75$
Time Estimate 0h45
Cost Estimate ~75$
Difficulty Easy
Vehicles
F-150 2014-2020 1
  • 3.0 V6 (PowerStroke) Diesel (991)

What is a Ford F-150 particulate filter?

Diesel engines and direct-injection petrol engines produce soot particles. The particulate filter (DPF/GPF) traps these harmful particles as exhaust gases pass through its honeycomb structure. It is placed on the exhaust line after the catalytic converter.

How does the Ford F-150 particulate filter work?

As soot accumulates, the filter periodically burns off (regenerates) the trapped particles. Active regeneration raises exhaust temperatures to 550–600°C, burning soot to ash. This occurs every 300–500 km during normal motorway driving. Vehicles driven only on short urban trips may not regenerate properly, leading to blockage.

When should you change the Ford F-150 particulate filter?

The DPF is designed to last 150,000–250,000 km but depends on driving patterns. Signs of needed replacement: DPF warning light, engine in limp mode, excessive exhaust smoke, or diagnostic scan showing excessive back-pressure or failed regeneration cycles.

Can the Ford F-150 particulate filter be cleaned instead of replaced?

Yes, professional DPF cleaning can restore a blocked filter at a fraction of replacement cost. However, if the filter substrate is cracked, melted, or structurally damaged, replacement is the only option. Never use a DPF removal/delete service — it is illegal and will fail the MOT/emissions test.

Is it difficult to change the Ford F-150 particulate filter?

Difficulty level 2/5: technically straightforward but physically demanding due to the filter's location and weight. Key steps: raise the vehicle, disconnect pressure sensors, remove exhaust clamps/bolts, lower the old DPF, fit the new one with new gaskets, reconnect sensors, clear fault codes, perform a forced regeneration cycle.

Related products →

8 generations covered

Generation Years Vehicles Fuel
F-150 1976-1979 1976-1979 4.9 Gas (94E), 5.0 Gas (N), 5.8 Gas (98H), 5.9 Gas (FE360), 6.4 Gas (FE390), 6.6 Gas (S400), 7.5 Gas (46075) Gas
F-150 1979-1992 1979-1992 3.8 V6 Gas (963), 4.9 Gas (94E), 5.0 Gas (N), 5.8 Gas (98H) Gas
F-150 1992-1997 1992-1997 4.9, -LPG LPG,Gas (99Y), 5.0 Gas (N), 5.0 Gas (N), 5.8 Gas (98H), 5.8 Gas (98H), 5.8 Lightning Gas (98H) Gas, LPG
F-150 1996-2004 1996-2004 4.2 Gas (992), 4.6 Gas (996), 4.6 Gas (996), 4.6 Gas (996), 4.6 Gas (99W), 5.4 Bi-Fuel CNG,Gas (99L), 5.4 CNG CNG (99L), 5.4 SOHC Gas (993), 5.4, -LPG LPG,Gas (99L), 5.4, -LPG LPG,Gas (99L), 5.4, -LPG LPG,Gas (99Z) CNG, Gas, LPG
F-150 2004-2009 2004-2009 4.2 Gas (992), 4.6 16V Gas (99W), 5.4 16V CNG CNG (99L), 5.4 16V Flex Fuel Gas (C54RSEM (99V)), 5.4 24V, -Flex fuel Gas (99L), 5.4 24V, -Flex fuel Gas (99L) CNG, Gas
F-150 2008-2014 2008-2014 3.5 (EcoBoost) Gas (C35PDTD (99T)), 3.7 V6 Ti-VCT, -Flex Fuel Gas (99M), 4.6 16V Gas (99W), 4.6 24V Gas (C46USEM (998)), 5.0 32V Ti-VCT, -Flex Fuel Gas (99F), 5.4 24V Flex Fuel Gas (99L), 6.2 Gas (C62RSEM (996)) Gas
F-150 2014-2020 2014-2020 2.7 V6 (EcoBoost) Gas (27PD0X (99P)), 3.0 V6 (PowerStroke) Diesel (991), 3.3 V6 Ti-VCT, -Flex Fuel Gas (T33PDED (99B)), 3.5 (EcoBoost) Gas (C35PDTD (99G)), 3.5 (EcoBoost) Gas (C35PDTD (99G)), 3.5 TI-VCT, -Flex Fuel Gas (C35PDED (998)), 5.0 Ti-VCT Flex Fuel Gas (C50SDEM (995)), 5… Diesel, Gas
F-150 2021-2025 2021-2025 3.0 TD V6 (PowerStroke) Diesel (991), 3.3 V6 Ti-VCT Gas (99B), 3.5 (EcoBoost) Gas (T35PDTD (998)), 5.0 V8 Ti-VCT Gas (995) Diesel, Gas

Other repair guides

Change Car Handbrake Cable

Very easy 0h30

Change Car Rear Silencer

Easy 1h30