Engines included:
- 2.0 VVT-i Gas (1AZ-FE)
- 2.4 Gas (2AZ-FE)
- EV Gas (EM)
Diagnostic Instructions
Connect an OBD scanner to your Toyota RAV4 2000-2006 to retrieve diagnostic fault codes.
Applies to: 2.0 VVT-i Gas (1AZ-FE)
Applies to: 2.4 Gas (2AZ-FE)
Steps:
- Connect OBD scanner to diagnostic port
- Turn ignition to ON position (engine off)
- Follow scanner instructions to read codes
- Record any codes displayed
- Consult service manual for code meanings
Fault Codes including 70 manufacturer-specific
Powertrain
| Code | Description |
|---|---|
| P0000 | Code reserved for ISO/SAE |
| P0001 | Fuel delivery control valve circuit/open |
| P0002 | Fuel delivery control valve circuit range/performance |
| P0003 | Fuel delivery control valve circuit low |
| P0010 | Inlet camshaft timing solenoid 1 circuit/open |
| P0011 | Inlet camshaft timing solenoid 1, timing over-advanced or system performance |
| P0012 | Inlet camshaft timing solenoid 1, timing over-retarded |
| P0013 | Exhaust camshaft timing solenoid 1 circuit/open |
| P0014 | Exhaust camshaft timing solenoid 1, timing over-advanced or system performance |
| P0015 | Exhaust camshaft timing solenoid 1, timing over-retarded |
| P0016 | Crankshaft position correlation with inlet camshaft position (bank 1) |
| P0017 | Crankshaft position correlation with exhaust camshaft position (bank 1) |
| P0030 | Oxygen sensor in front of catalytic converter 1, heating circuit/open |
| P0031 | Oxygen sensor in front of catalytic converter 1, heating control circuit low |
| P0033 | Turbocharger bypass valve circuit/open |
| P0036 | Oxygen sensor behind catalytic converter 1, heating circuit/open |
| P0037 | Oxygen sensor behind catalytic converter 1, heating control circuit low |
| P0045 | Turbo pressure control solenoid 1 circuit/open |
| P0046 | Turbo pressure control solenoid 1 circuit range/performance |
| P0047 | Turbo pressure control solenoid 1 circuit low |
| P0053 | Oxygen sensor in front of catalytic converter 1, heater resistance |
| P0054 | Oxygen sensor behind catalytic converter 1, heater resistance |
| P005A | Exhaust camshaft profile control performance/stuck off (bank 1) |
| P0068 | MAP sensor/mass airflow meter correlation with throttle position sensor |
| P0069 | MAP sensor correlation with barometric pressure sensor |
| P0070 | Ambient air temperature sensor circuit/open |
| P0071 | Ambient air temperature sensor circuit range/performance |
| P0073 | Ambient air temperature sensor circuit high |
| P0087 | Fuel rail/system pressure too low |
| P0088 | Fuel rail/system pressure too high |
| P0089 | Fuel pressure control valve 1 performance |
| P0090 | Fuel pressure control valve 1 circuit/open |
| P0091 | Fuel pressure control valve 1 circuit low |
| P0093 | Fuel system, major leakage detected |
| P0094 | Fuel system, minor leakage detected |
| P0095 | Air temperature sensor 2 circuit/open |
| P0096 | Air temperature sensor 2 circuit range/performance |
| P0098 | Air temperature sensor 2 circuit high |
| P00BC | Mass airflow meter 1 circuit range/performance, airflow too low |
| P00BD | Mass airflow meter 1 circuit range/performance, airflow too high |
| P0100 | Mass airflow meter 1 circuit/open |
| P0101 | Mass airflow meter 1 circuit range/performance |
| P0102 | Mass airflow meter 1 circuit low |
| P0103 | Mass airflow meter 1 circuit high |
| P0104 | Mass airflow meter 1 circuit intermittent |
| P0105 | MAP sensor/barometric pressure sensor circuit/open |
| P0106 | MAP sensor/barometric pressure sensor circuit range/performance |
| P0107 | MAP sensor/barometric pressure sensor circuit low |
| P0108 | MAP sensor/barometric pressure sensor circuit high |
| P0110 | Air temperature sensor 1 circuit/open |
| P0112 | Air temperature sensor 1 circuit low |
| P0113 | Air temperature sensor 1 circuit high |
| P0115 | Coolant temperature sensor 1 circuit/open |
| P0116 | Coolant temperature sensor 1 circuit range/performance |
| P0117 | Coolant temperature sensor 1 circuit low |
| P0118 | Coolant temperature sensor 1 circuit high |
| P0120 | Throttle position sensor 1 circuit/open Accelerator pedal position sensor 1 circuit/open |
| P0121 | Accelerator pedal position sensor 1 range/performance Throttle position sensor 1 range/performance |
| P0122 | Throttle position sensor 1 circuit low Accelerator pedal position sensor 1 circuit low |
| P0123 | Accelerator pedal position sensor 1 circuit high Throttle position sensor 1 circuit high |
| P0128 | Coolant thermostat (coolant temperature below thermostat regulating temperature) |
| P012C | Turbocharger inlet pressure sensor 1 circuit low |
| P0130 | Oxygen sensor in front of catalytic converter 1, circuit/open |
| P0131 | Oxygen sensor in front of catalytic converter 1, circuit low |
| P0132 | Oxygen sensor in front of catalytic converter 1, circuit high |
| P0133 | Oxygen sensor in front of catalytic converter 1, slow response |
| P0134 | Oxygen sensor in front of catalytic converter 1, circuit, no activity detected |
| P0135 | Oxygen sensor in front of catalytic converter 1, heating circuit/open |
| P0136 | Oxygen sensor behind catalytic converter 1, circuit/open |
| P0137 | Oxygen sensor behind catalytic converter 1, circuit low |
| P0138 | Oxygen sensor behind catalytic converter 1, circuit high |
| P0139 | Oxygen sensor behind catalytic converter 1, circuit, slow response |
| P0140 | Oxygen sensor behind catalytic converter 1, circuit, no activity detected |
| P0141 | Oxygen sensor behind catalytic converter 1, heating circuit/open |
| P0170 | Fuel trim (bank 1) |
| P0171 | System too lean (bank 1) |
| P0172 | System too rich (bank 1) |
| P0174 | System too lean (bank 2) |
| P0180 | Fuel temperature sensor 1 circuit/open |
| P0183 | Fuel temperature sensor 1 circuit high |
| P0190 | Fuel pressure sensor 1 circuit/open |
| P0191 | Fuel pressure sensor 1 circuit range/performance |
| P0192 | Fuel pressure sensor 1 circuit low |
| P0193 | Fuel pressure sensor 1 circuit high |
| P0200 | Injector circuit/open |
| P0201 | Injector 1 circuit/open |
| P0202 | Injector 2 circuit/open |
| P0203 | Injector 3 circuit/open |
| P0204 | Injector 4 circuit/open |
| P0215 | Fuel shut-off solenoid circuit/open |
| P0217 | Engine overheat |
| P0220 | Throttle position sensor 2 circuit/open Accelerator pedal position sensor 2 circuit/open |
| P0221 | Throttle position sensor 2 circuit range/performance Accelerator pedal position sensor 2 range/performance |
| P0222 | Throttle position sensor 2 circuit low Accelerator pedal position sensor 2 circuit low |
| P0225 | Throttle/pedal position sensor 3 circuit/open |
| P0226 | Throttle/pedal position sensor 3 circuit range/performance |
| P0230 | Fuel pump primary circuit/open |
| P0234 | Engine overboost |
| P0235 | Boost pressure sensor 1 circuit/open |
| P0236 | Boost pressure sensor 1 circuit range/performance |
| P0237 | Boost pressure sensor 1 circuit low |
| P0238 | Boost pressure sensor 1 circuit high |
| P0243 | Turbo pressure control solenoid 1 circuit/open |
| P0244 | Turbo pressure control solenoid 1 circuit range/performance |
| P0245 | Turbo pressure control solenoid 1 circuit low |
| P0251 | Injection pump fuel metering control 1 (cam/rotor/injector) |
| P0262 | Injector 1 circuit high |
| P0263 | Cylinder 1 contribution/balance |
| P0265 | Injector 2 circuit high |
| P0266 | Cylinder 2 contribution/balance |
| P0268 | Injector 3 circuit high |
| P0269 | Cylinder 3 contribution/balance |
| P0271 | Injector 4 circuit high |
| P0272 | Cylinder 4 contribution/balance |
| P0299 | Turbocharger/supercharger underboost |
| P02ED | (Diesel) Inlet airflow control system, low airflow detected |
| P0300 | Random/multiple cylinder misfire detected |
| P0301 | Cylinder 1 misfire detected |
| P0302 | Cylinder 2 misfire detected |
| P0303 | Cylinder 3 misfire detected |
| P0304 | Cylinder 4 misfire detected |
| P0313 | Misfire detected with low fuel |
| P0321 | Crankshaft position sensor/engine speed sensor input circuit range/performance fault |
| P0322 | Crankshaft position sensor/engine speed sensor input circuit, no signal |
| P0325 | Knock sensor 1 circuit/open |
| P0327 | Knock sensor 1 circuit low |
| P0335 | Crankshaft position sensor 1 circuit/open |
| P0336 | Crankshaft position sensor 1 circuit range/performance |
| P0337 | Crankshaft position sensor 1 circuit low |
| P0339 | Crankshaft position sensor 1 circuit intermittent |
| P0340 | Inlet camshaft position sensor 1 circuit/open |
| P0341 | Inlet camshaft position sensor 1 circuit range/performance |
| P0342 | Inlet camshaft position sensor 1 circuit low |
| P0343 | Inlet camshaft position sensor 1 circuit high |
| P0344 | Inlet camshaft position sensor 1 circuit intermittent |
| P0351 | Ignition coil 1 primary control circuit/open |
| P0352 | Ignition coil 2 primary control circuit/open |
| P0365 | Exhaust camshaft position sensor 1 circuit/open |
| P0369 | Exhaust camshaft position sensor 1 circuit intermittent |
| P0380 | Glow plug/heater circuit 1 |
| P0381 | Glow plug/heater indicator circuit/open |
| P0400 | EGR flow |
| P0401 | EGR, insufficient flow |
| P0402 | EGR, excessive flow. |
| P0403 | EGR control circuit/open |
| P0404 | EGR control circuit range/performance |
| P0405 | EGR sensor 1 circuit low |
| P0406 | EGR sensor 1 circuit high |
| P0407 | EGR sensor 2 circuit low |
| P0409 | EGR sensor 1 circuit/open |
| P0410 | Secondary air injection system |
| P0420 | Catalytic converter system efficiency below threshold (bank 1) |
| P0421 | Catalytic converter quick warm-up, efficiency below threshold (bank 1) |
| P0428 | Catalytic converter temperature sensor in front of catalytic converter 1, circuit high |
| P042F | EGR throttle control 1 stuck closed |
| P0430 | Catalytic converter system efficiency below threshold (bank 2) |
| P0441 | Evaporative emission system incorrect purge flow |
| P0443 | Evaporative emission system purge control valve circuit/open |
| P0444 | Evaporative emission system purge control valve circuit/open |
| P0460 | Fuel level sensor 1 circuit/open |
| P0463 | Fuel level sensor 1 circuit high |
| P046C | EGR sensor 1 circuit range/performance |
| P0470 | Exhaust pressure sensor 1 circuit/open |
| P0471 | Exhaust pressure sensor 1 circuit range/performance |
| P0472 | Exhaust pressure sensor 1 circuit low |
| P0473 | Exhaust pressure sensor 1 circuit high |
| P0480 | Fan 1 control circuit/open |
| P0481 | Fan 2 control circuit/open |
| P0483 | Cooling fan control check |
| P0485 | Fan power/ground circuit/open |
| P0487 | EGR throttle control 1 circuit/open |
| P0488 | EGR throttle control 1 circuit range/performance |
| P0489 | EGR throttle control 1 circuit low |
| P0490 | EGR throttle control 1 circuit high |
| P0493 | Fan overspeed |
| P0494 | Fan 1 speed low |
| P0495 | Fan 1 speed high |
| P049A | EGR 2, flow range/performance |
| P049B | EGR 2, insufficient flow |
| P0500 | Vehicle speed sensor 1 circuit/open |
| P0501 | Vehicle speed sensor 1 range/performance |
| P0504 | Brake pedal switch correlation with brake light switch |
| P0507 | Idle air control system rpm higher than expected |
| P0520 | Oil pressure sensor/switch circuit/open |
| P0521 | Oil pressure sensor/switch circuit range/performance |
| P0530 | Refrigerant pressure sensor 1 circuit/open |
| P0532 | Refrigerant pressure sensor 1 circuit low |
| P0544 | Exhaust gas temperature sensor in front of catalytic converter 1, circuit/open |
| P0545 | Exhaust gas temperature sensor in front of catalytic converter 1, circuit low |
| P0546 | Exhaust gas temperature sensor in front of catalytic converter 1, circuit high |
| P0560 | System voltage |
| P0562 | System voltage low |
| P0563 | System voltage high |
| P0564 | Cruise control multifunction input circuit/open |
| P0571 | Brake switch 1 circuit/open |
| P0597 | Thermostat heating control circuit/open |
| P0598 | Thermostat heating control circuit low |
| P0600 | Serial communication link |
| P0601 | Control unit internal fault, memory checksum |
| P0603 | Control unit internal fault, keep alive memory (KAM) |
| P0606 | Engine control unit/powertrain control unit processor |
| P0607 | Control unit performance |
| P060A | Control unit internal monitoring, processor performance |
| P0620 | Alternator control circuit/open |
| P062B | Control unit internal fault, fuel injector control performance |
| P0638 | Throttle actuator control range/performance |
| P0641 | Sensor reference voltage 1 circuit/open |
| P0657 | Actuator supply 1 voltage circuit/open |
| P0670 | Glow plug control unit control circuit/open |
| P0671 | Glow plug 1 circuit/open |
| P0672 | Glow plug 2 circuit/open |
| P0683 | Glow plug control unit 1 to powertrain control unit, communication circuit/open |
| P0684 | Glow plug control unit 1 to powertrain control unit, communication circuit range/performance |
| P0685 | Main relay control circuit/open |
| P0686 | Main relay control circuit low |
| P068A | Engine control unit/powertrain control unit, power relay de-energising too quickly |
| P0691 | Fan 1 control circuit low |
| P06B8 | Internal control unit non-volatile random access memory (NVRAM) fault |
| P0700 | Transmission control system MIL request |
| P0704 | Clutch switch input circuit/open |
| P0705 | Transmission range sensor 1 circuit/open (PRNDL input) Transmission control unit (TCM), invalid signal |
| P0710 | Transmission fluid temperature sensor 1 circuit/open |
| P0711 | Transmission fluid temperature sensor 1 circuit range/performance |
| P0726 | Engine speed input circuit range/performance |
| P0741 | Torque converter solenoid circuit performance/stuck off |
| P0805 | Clutch position sensor circuit/open |
| P0868 | Transmission fluid pressure low |
| P1100 | Disponible dans le produit |
| P1101 | Disponible dans le produit |
| P1113 | Disponible dans le produit |
| P1125 | Disponible dans le produit |
| P1130 | Disponible dans le produit |
| P1135 | Disponible dans le produit |
| P1161 | Disponible dans le produit |
| P1164 | Disponible dans le produit |
| P1166 | Disponible dans le produit |
| P1197 | Disponible dans le produit |
| P1198 | Disponible dans le produit |
| P11A8 | Disponible dans le produit |
| P1336 | Disponible dans le produit |
| P1337 | Disponible dans le produit |
| P1338 | Disponible dans le produit |
| P1339 | Disponible dans le produit |
| P1340 | Disponible dans le produit |
| P1349 | Disponible dans le produit |
| P1350 | Disponible dans le produit |
| P1351 | Disponible dans le produit |
| P1352 | Disponible dans le produit |
| P1403 | Disponible dans le produit |
| P1404 | Disponible dans le produit |
| P1412 | Disponible dans le produit |
| P1434 | Disponible dans le produit |
| P1435 | Disponible dans le produit |
| P1446 | Disponible dans le produit |
| P1461 | Disponible dans le produit |
| P1471 | Disponible dans le produit |
| P1500 | Disponible dans le produit |
| P1536 | Disponible dans le produit |
| P1541 | Disponible dans le produit |
| P1570 | Disponible dans le produit |
| P1586 | Disponible dans le produit |
| P15A1 | Disponible dans le produit |
| P15A4 | Disponible dans le produit |
| P15B3 | Disponible dans le produit |
| P1600 | Disponible dans le produit |
| P1602 | Disponible dans le produit |
| P1604 | Disponible dans le produit |
| P1612 | Disponible dans le produit |
| P1621 | Disponible dans le produit |
| P1631 | Disponible dans le produit |
| P1632 | Disponible dans le produit |
| P1641 | Disponible dans le produit |
| P1645 | Disponible dans le produit |
| P1654 | Disponible dans le produit |
| P1664 | Disponible dans le produit |
| P1693 | Disponible dans le produit |
| P1694 | Disponible dans le produit |
| P1735 | Disponible dans le produit |
| P1755 | Disponible dans le produit |
| P2000 | NOx trap efficiency below threshold (bank 1) |
| P2002 | Diesel/petrol particulate filter efficiency below threshold (bank 1) |
| P2006 | Inlet manifold runner control stuck closed (bank 1) |
| P2008 | Inlet manifold runner control circuit/open (bank 1) |
| P200A | Inlet manifold runner control circuit range/performance (bank 1) |
| P2015 | Inlet manifold runner position sensor/switch circuit range/performance (bank 1) |
| P2020 | Inlet manifold runner position sensor/switch circuit range/performance (bank 2) |
| P2022 | Inlet manifold runner position sensor/switch circuit high (bank 2) |
| P2032 | Exhaust gas temperature sensor behind the catalytic converter, circuit low (bank 1) |
| P2033 | Exhaust gas temperature sensor behind the catalytic converter, circuit high (bank 1) |
| P203F | Reductant level low |
| P2047 | Reductant injector 1 circuit/open (bank 1) |
| P2048 | Reductant injector 1 circuit low (bank 1) |
| P2084 | Exhaust gas temperature sensor behind the catalytic converter, circuit range/performance (bank 1) |
| P208E | Reductant injector 1 stuck closed (bank 1) |
| P2096 | Post-catalytic converter fuel trim system too lean (bank 1) |
| P20A2 | Reductant purge control solenoid circuit low |
| P20E8 | Reductant pressure too low |
| P20E9 | Reductant pressure too high |
| P20EE | NOx catalytic converter system efficiency below threshold (bank 1) |
| P20F6 | Reductant injector 1 stuck open (bank 1) |
| P2100 | Throttle actuator control motor circuit/open |
| P2101 | Throttle actuator control motor circuit range/performance |
| P2108 | Throttle actuator control unit performance |
| P2125 | Throttle/pedal position sensor 5 circuit/open |
| P2127 | Throttle/pedal position sensor 5 circuit low |
| P2138 | Throttle/pedal position sensor 4 correlation with throttle/pedal position sensor 5 |
| P2143 | EGR vent control circuit/open |
| P2177 | System too lean off idle (bank 1) |
| P2187 | System too lean at idle speed (bank 1) |
| P2196 | Oxygen sensor in front of catalytic converter 1, signal biased/stuck rich |
| P2200 | NOx sensor 1 circuit/open |
| P2201 | NOx sensor 1 circuit range/performance |
| P2204 | NOx sensor 1 circuit intermittent |
| P2237 | Oxygen sensor in front of catalytic converter 1, positive current control circuit/open |
| P2243 | Oxygen sensor in front of catalytic converter 1, reference voltage circuit/open |
| P2244 | Oxygen sensor in front of catalytic converter 1, reference voltage, performance |
| P2251 | Oxygen sensor in front of catalytic converter 1, negative current control circuit/open |
| P2263 | Turbocharger/supercharger boost system performance |
| P2264 | Water separator sensor circuit/open |
| P2271 | Oxygen sensor behind catalytic converter 1, sensor signal stuck rich |
| P2279 | Inlet air system leakage |
| P2291 | Injector control pressure too low, engine cranking |
| P2297 | Oxygen sensor in front of catalytic converter 1, out of range during deceleration |
| P229F | NOx sensor 2 heater circuit range/performance (bank 1) |
| P22AE | Oxygen sensor behind the catalytic converter, reference voltage circuit/open (bank 1) |
| P2408 | Fuel cap sensor/switch circuit/open |
| P2413 | EGR system performance |
| P2425 | EGR cooling valve control circuit/open |
| P242A | Exhaust gas temperature sensor behind catalytic converter 3, circuit/open |
| P242B | Exhaust gas temperature sensor behind catalytic converter 3, circuit range/performance |
| P242F | Diesel/petrol particulate filter restriction caused by ash accumulation |
| P244A | Diesel/petrol particulate filter differential pressure too low (bank 1) |
| P244B | Diesel/petrol particulate filter differential pressure too high (bank 1) |
| P244C | Exhaust gas temperature too low for diesel/petrol particulate filter regeneration (bank 1) |
| P2452 | Diesel/petrol particulate filter differential pressure sensor circuit/open |
| P2453 | Diesel/petrol particulate filter differential pressure sensor circuit range/performance |
| P2455 | Diesel/petrol particulate filter differential pressure sensor circuit high |
| P2458 | Diesel/petrol particulate filter regeneration duration |
| P2463 | Clogged diesel/petrol particulate filter |
| P246C | Diesel/petrol particulate filter restriction, forced limited performance (bank 1) |
| P24A4 | Diesel/petrol particulate filter restriction caused by soot accumulation (bank 1) |
| P2562 | Turbocharger boost control position sensor 1 circuit/open |
| P2563 | Turbocharger boost control position sensor 1 circuit range/performance |
| P2564 | Turbocharger boost control position sensor 1 circuit low |
| P2565 | Turbocharger boost control position sensor 1 circuit high |
| P2566 | Turbocharger boost control position sensor 1 circuit intermittent |
| P2598 | Turbocharger boost control position sensor 1 performance, stuck low |
| P2600 | Coolant pump control circuit/open |
| P2620 | Throttle position output circuit/open |
| P2BAC | NOx maximum value exceeded, EGR deactivated |
| P3007 | Disponible dans le produit |
| P3008 | Disponible dans le produit |
| P3102 | Disponible dans le produit |
Body
| Code | Description |
|---|---|
| B0001 | Driver's airbag, first stage deployment control circuit |
| B1000 | Disponible dans le produit |
| B1003 | Disponible dans le produit |
| B124D | Disponible dans le produit |
| B1400 | Disponible dans le produit |
| B1805 | Disponible dans le produit |
| B1811 | Disponible dans le produit |
| B2799 | Unmatched key code Engine Immobiliser System Malfunction |
Chassis
| Code | Description |
|---|---|
| C003A | Right rear wheel speed sensor |
| C0040 | Brake pedal switch A |
| C1020 | Disponible dans le produit |
| C1200 | Disponible dans le produit |
| C1201 | Disponible dans le produit |
| C1380 | Disponible dans le produit |
| C156D | Disponible dans le produit |
Network
| Code | Description |
|---|---|
| U0001 | High-speed CAN communication bus |
| U0026 | Low-speed CAN communication bus (-) circuit high |
| U0073 | Control unit communication bus A off |
| U0100 | Lost communication with engine control unit/ powertrain control unit A |
| U0101 | Lost communication with the transmission control unit (TCM) |
| U0121 | Lost communication with the ABS control unit CAN-Bus no communication with the electronic brake control unit (EBCM) |
| U0140 | Lost communication with the body control unit (BCM) Lost communication with the body control unit |
| U0155 | Lost communication with the instrument panel cluster (IPC) control unit |
| U0401 | Invalid data received from the engine control unit/powertrain control unit |
| U0415 | Invalid data received from the ABS control unit |
| U0416 | Invalid data received from the vehicle dynamics control unit |
| U0422 | Invalid data received from the body control unit |
| U0426 | Invalid data received from the immobiliser control unit |
| U059E | Invalid data received from NOx sensor A |
| U1000 | Disponible dans le produit |
| U1113 | Disponible dans le produit |
| U1400 | Disponible dans le produit |
| U1401 | Disponible dans le produit |
| U2FFF | Lighting of diagnostics warning lamp and display of message "Electric drive train fault" when driving, followed by an intermittent failure to start (7 kW charger) |
